Table of Contents
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Why does my golf cart jerk when I accelerate?
The most common problem here is likely an issue with the batteries. If the battery is low on power or doesn’t distribute power properly, then the cart may jerk as it accelerates. Messing up the clutch or the MCOR is going to cause your cart to become even more jerky.
What are the symptoms of a bad solenoid in a golf cart?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
Why does my electric golf cart hesitate?
If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.
Should you leave your electric golf cart plugged in all the time?
Caring for your golf cart battery with regular charging is a way to extend its longevity. However, experts advise not to leave your cart unplugged all the time. It is essential for golf cart batteries to undergo a charge-discharge-recharge cycle for durability.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller Failure Top Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. Sudden and Unexpected Slowing. Shuttering or Shaky Driving. Stalling Out and Refusing to Start. Surges in Speed When Driving.
What makes a golf cart jump?
A gasoline golf cart will just need a temporary burst of electricity that helps the engine run, allowing the alternator to charge up the battery. However, an electric cart needs not only a jump but a consistent flow of electricity to charge the battery properly.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won’t start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you troubleshoot an electric golf cart?
How to Troubleshoot an Electric Golf Cart Test the wall socket where you charge your cart. Every golf cart has a built-in charger that connects to a wall socket. Expose your golf cart batteries. Test the batteries for voltage. Replace dead batteries. Expose the motor for inspection. Reset the motor. Test the cart.
How do I reset my electric golf cart motor?
First, you’ll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
How often should you check golf cart batteries?
You should aim to check the water level in your battery cells every at least once every two months to ensure that your battery isn’t ask risk of being ruined due to low water levels. The best time to refill the water in your golf cart batteries is immediately after fully charging your golf cart.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
How often do you need to add water to golf cart batteries?
After charging your battery is when you want to add water. Adding water after charging prevents acid from spilling over. You’ll want to add water to 1/2 inch from the top of the battery. 2) We recommend service once or twice a year.
How often do golf cart batteries need water?
One integral aspect of this maintenance is battery watering. Unless you have a sealed battery, you should check the water level of your battery at regular intervals, usually about once a month, to ensure it is within the recommended range.
Can you overcharge golf cart batteries?
Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Do not drive the vehicle until the battery dies; lead-acid batteries won’t last as long if you completely discharge them.
How do you test an electric golf cart controller?
Connect the negative probe to the controller’s M terminal and positive probe to the B+ terminal. Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor.
When Should golf cart batteries be replaced?
Here are 4 signs you need to replace your golf cart batteries: It takes twice as long to charge your batteries as it did when you first had them installed. Your Golf Cart loses power very quickly. Your Golf Cart does not accelerate as fast as it used to. The batteries are leaking acid and are beginning to bulge.
What controls the speed on an electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that’s located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
How long do electric golf cart motors last?
When properly taken care of, the typical gas or electric golf cart motor can last many, many years (20 to 30+). But the fact of the matter is, many people neglect taking proper care of their golf cart motor.
