Table of Contents
On the older Club cars, the tow/run switch is located at the top of the battery compartment toward the front under the seat and also at the top in the middle of the four twelve volt batteries. The later Precedents have the tow/run switch located in the lower middle in the rear of the battery compartment.
What is the tow run switch on Club Car?
The tow run switch, also sometimes called a tow maintenance switch, is present in many brands and models of modern golf carts. This switch is only installed into golf carts with a separately excited motor which produces regenerative braking. They are not used in traditional golf carts with a series wound motor.
Do all club cars have tow run switches?
Usually, a TOW / RUN switch is only used on electric golf carts, specifically those with a separately excited electrical system with regenerative braking. They are not needed with electric golf carts with a series wound electrical system.
Does golf cart have to be in tow mode to charge?
Yes, you can charge your golf cart in tow mode. Though this mode does cause your cart to switch off its computer, that doesn’t mean that it affects the battery or other elements of your cart.
How do you reset a Club Car golf cart?
Easily Reset the Club Car Golf Cart OBC Key switch to off. Set forward/reverse to neutral. Put tow/run switch to tow. Disconnect the negative battery terminal from the battery pack. Put the tow/run switch to run. Put forward/reverse switch to reverse. Put key switch to on.
Should I leave my golf cart plugged in all the time?
A golf cart battery is supposed to charge and discharge and recharge again in that cycle while it last. Leaving your golf cart plugged all the time is not an ideal maintenance practice for the longevity of your battery. The minimum maintenance for a battery is recharging it soon after use; unplug it when fully charged.
Can you tow a golf cart behind a car?
Can You Tow a Car and Golf Cart Together? If you have a sturdy towing vehicle, you could tow your car and golf cart together. You’ll need a tow dolly with room for your golf cart to sit on the trailer. The front of your vehicle attaches to the dolly while the back wheels trail on the highway.
Can you tow an electric golf cart?
Whether your golf cart is gas-powered or electric, moving the cart just takes a few steps and can be done easily. Any time your golf cart needs towed or dies, you must use the “tow-run” switch on the cart and switch it to the “TOW” position.
What is tow mode on a Club Car golf cart?
Utilizing tow mode will allow for the most efficient charging practices. Storing your golf cart for an extended period of time. Utilize tow mode to prevent battery from draining. In summary, your golf cart’s tow mode disables the vehicle’s electronic speed controller and its roll away protection.
How do you charge a Club Car golf cart?
Plug in the charging plug into the plug on the Club Car battery charger, making sure the two of them are secure. Select the appropriate voltage on the battery charger for the number of batteries that you have on the golf cart. If you have 3 batteries, select 36 volts, and if you have 4, select 48 volts.
Will a 48 volt charger charge a 36 volt golf cart?
No. You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger.
How do you troubleshoot a Club Car golf cart?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance. Test the wall socket where you charge your cart. Expose your golf cart batteries. Test the batteries for voltage. Replace dead batteries. Expose the motor for inspection. Reset the motor. Test the cart.
How do I test my club car onboard computer?
Is My Club Car Golf Cart on Board Computer (OBC) Bad? Set the voltage meter to DC Volts 200V. Take voltage from the positive side of the charger port/receptacle to the negative on the battery pack loop of batteries. There should be voltage read on the battery back, this may vary based on the charge.
How long does it take to charge a Club Car golf cart?
It takes 8 to 14 hours to charge a fully discharged battery pack whether you have an old or new battery. Factors that can determine charging time are depth of discharge, how many amp-hours you have used, as well as how many amp hours your charger can charge.
What does yellow light on Club Car mean?
The battery light on Club Car golf carts is only on battery-powered models and indicates that the battery for the cart is running low. When this warning light is activated, the cart should be charged immediately.
What does the blue light on a Club Car charger mean?
The light comes on and remains solid when the battery state of charge falls below 20%. The light begins flashing when the battery state of charge falls below 10%.
How often do golf cart batteries need water?
One integral aspect of this maintenance is battery watering. Unless you have a sealed battery, you should check the water level of your battery at regular intervals, usually about once a month, to ensure it is within the recommended range.
Can you overcharge golf cart batteries?
Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Do not drive the vehicle until the battery dies; lead-acid batteries won’t last as long if you completely discharge them.
