Where Is The Reset Button On A Club Car Golf Cart

Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.

Is there a reset button on a Club Car golf cart?

Club Car uses the On Board Computer or OBC to monitor and control functions of their golf carts. If you disconnect the controller from the golf cart will cause a soft reset of the of the OBC when the battery power is removed. Once the battery powered is removed, the OBC internals will clear any faults.

Where is the reset button on an electric golf cart motor?

First, you’ll want to reset your motor. Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor.

Do all golf cart motors have a reset button?

Carefully remove them with a screwdriver. Then reset your cart’s motor; most golf cart electric motors contain a special button designed to reset the motor by behaving like a tiny circuit breaker. You will usually find this button―you can’t miss it; it’s red!Nov 15, 2016.

Where is the fuses on a Club Car golf cart?

Finally, there is the 400-amp fuse, which is almost always located as near the power source or the battery as possible on your cart. Often, it is located on the positive or negative terminal of a battery to make it easier to access.

How do you troubleshoot a Club Car golf cart?

There are a few simple problems that you can fix yourself that will not necessitate professional maintenance. Test the wall socket where you charge your cart. Expose your golf cart batteries. Test the batteries for voltage. Replace dead batteries. Expose the motor for inspection. Reset the motor. Test the cart.

What does the orange light mean on a Club Car golf cart?

The battery light is an icon of a battery. This light only becomes illuminated on the dash when the vehicle’s battery is low. This light is illuminated when approximately 10 percent of the vehicle’s battery life remains.

How do I reset my Club Car Precedent?

The reset process is easy to do, but can take a fair amount of time. The reverse buzzer will sound and go off in about 30 seconds. Leave the cart like that for 5 min to cause the OBC to reset. Reconnect the Batt – wire to the battery minus terminal on the battery pack.

How do I know if my golf cart motor is bad?

You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won’t start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.

What happens when an electric motor burns out?

When a motor burns out, a short circuit occurs in the windings and the motor ceases to turn. You can test for a short circuit by checking the resistance of the windings with an ohmmeter; a reading of 0 ohms (Ω) indicates a short.

What can go wrong with an electric golf cart?

5 Common Electric Golf Cart Problems and How to Solve Them Troubleshooting Batteries. Like any electric vehicle, the battery is often the root of the problem. Ignition or Motor Issues. Solenoid Woes. Faulty Direction Switch. No Speed Control.

What would cause a golf cart not to move?

Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.

How do you check a fuse on a golf cart?

Find the service panel on the rear fender on the driver side of the golf cart behind the battery. Read the inside panel to determine the level of current the fuses are set to take at a maximum voltage. It is common for fuses to be 250V.

Is there a fuse for the lights on a golf cart?

The Various Parts of a Golf Cart’s Lighting System These parts of the system are responsible for producing light. In addition to the actual bulbs, the lighting system is also composed of fuses and the lighting switch. The fuses act as the safety patrol of the lighting system.

Where are fuse boxes located?

Look for the fuse box in closets, hallways, mudrooms, crawl spaces, basements, utility rooms, or laundry rooms. Fuse boxes in more prominent locations might be covered with a wood panel or picture meant to disguise the appearance of the box cover or door.

How do you reset an electric golf cart?

Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.

How do I know if my club car controller is bad?

X Common Symptoms of Controller Failure Top Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. Sudden and Unexpected Slowing. Shuttering or Shaky Driving. Stalling Out and Refusing to Start. Surges in Speed When Driving.