Table of Contents
The fan relay is usually located near the bottom of the engine compartment on a metal frame member. The metal acts as a heat sink to keep the fan relay cool. So, unplug the connector at the relay and repeat the check for power.
Which relay is for radiator fan?
The cooling fan relay is normally located in either the underhood fuse and relay center or mounted to the electric fan assembly behind the radiator.
How do I know if my radiator fan relay is bad?
Bad Cooling Fan Relay Symptoms The engine runs hot or overheats. The cooling fans don’t work. The cooling fans keep running. Warning lights. Poor air conditioning performance. Swapping Relays. Measuring the Relay Coil’s Resistance. Listening for Noises.
Where is the fuse located for the fan?
If you don’t see one that says fan or cooling fan, you will need to find the cabin fuse box. This is located in different places, again dependent on the manufacturer and model. Some times it is located behind the glove compartment, sometimes on the lower, left end of the dash board.
Is there a fuse for the radiator fan?
If your car’s radiator fan is non-functional, check your car’s user manual and locate the fuse for the radiator fan controller or the fan. The fan itself often uses a big fuse of around 50A, while there might also be a separate small fuse to the fan control module.
What causes a fan relay to burn out?
If overvoltage is applied to the coil, the coil’s insulating film will be destroyed, and short-circuiting will cause high temperature. The color of the coil will change, and the resin around the coil will melt.
What causes a cooling fan not to work?
ELECTRIC COOLING FAN PROBLEMS Defective temperature switch, coolant sensor or other sensor. Engine thermostat is stuck OPEN (engine never gets hot enough to turn on the fan) Faulty fan relay. A wiring problem (blown fuse, loose or corroded connector, shorts, opens, etc.).
How much does a cooling fan relay cost?
To get your cooling fan relay replaced, you will pay, on average, $80-$160, depending on the type of car you have and the mechanic’s fees. The labor should cost around $70, while parts should run you $10-$50.
Where is the fan module located?
The cooling fan control module in your vehicle is located at the front left of the engine compartment next to the radiator.
Where is the radiator fan located?
The car radiator fan is found between the engine and the radiator, although some radiator fans are found at the front or anterior part of the radiator. Electric fans are found in the front part of the radiator and are also referred to as “pusher fans”.
Where is the fan relay on a 2011 Ford Edge?
The cooling fan fuse is located in the under hood fuse box at location c432 on the 2011 ford edge.
How can you tell if a fan fuse is blown?
Look at the fuse wire. If there is a visible gap in the wire or a dark or metallic smear inside the glass then the fuse is blown and needs to be replaced.
What causes a relay to overheat?
The only reason a DC relay would overheat is that it’s being run above its rated voltage. An AC relay, on the other hand, draws a variable current. Initially, when it’s open, the inductance is low so the current is high.
How do relays get damaged?
In fact, the life of a relay is essentially determined by the life of its contacts. Degradation of contacts is caused from high in-rush currents, high- sustained currents, and from high voltage spikes. Relays can also fail due to poor contact alignment and open coils.
Is it possible to short out a relay?
Relay Safety Relay testing is a simple process, but don’t skip out on safety. The wrong relay can cause a short or a power surge that can damage your vehicle’s electrical system. Handle the relay gingerly and try to avoid dropping it. If the relay is damaged internally, it can cause burning or melting of wiring.
Can I drive without a radiator fan?
Yes, technically your engine does not need a cooling fan to operate. If the radiator does not have cool air blowing on it constantly, it will overheat eventually, so you’d need the perfect combination of weather and traffic to drive effectively without a radiator fan.
Can AutoZone test relays?
When it’s time to swap out your faulty relays, AutoZone has the solution to upgrade your vehicle without breaking the bank. After conducting a simple electrical test, you can indicate if you need to replace an ignition relay.
How much does a relay cost?
How Much Does a Relay Cost? An aftermarket relay usually costs around $50 to $250. Prices can vary depending on various factors, like its brand, quantity, product fit, and condition. Labor costs for this type of replacement usually range from $30 to $60.
What does it mean when your car fan keeps running when car is off?
It’s normal for some vehicles to have a fan run for a few minutes after the car is shut off, generally to keep the engine cool. However, if the fan is running for an extended period, the fan itself can become damaged due to overuse. It’s possible you may have a module or relay failing in your car.
Why does my fan keep going after I turn my car off?
When the coolant within the radiator reaches a specified temperature, the sensor activates the fan, and it will continue to run even after you turn of the car engine. This normal. You should always ask your auto mechanic to check the cool fans when the car is in for service.
How much does it cost to get a radiator fan replace?
The average radiator fan replacement cost is typically between $550 and $650. In many cases, the radiator fan will cost around $400 to $450, while the labor adds $150 to $200. However, some vehicles can be more expensive, depending on the design.
