Table of Contents
How do you bypass the governor on a EZ Go golf cart?
General Instructions Detach the cable from the carburetor. The cable is about the width of a straw. Follow the disconnected cable up to the governor. Disconnect the gas pedal cable from the governor and reroute it to the carburetor. Using your wrench, remove the bolt on the gas pedal shaft.
How can I make my gas golf cart go faster?
6 Ways You Can Make a Golf Cart Faster Add More Torque to Your Golf Cart. Upgrade Your Golf Cart’s Motor. Improve the High-Speed Controller of the Cart. Add Better Golf Cart Tires. Use a Higher Powered Golf Cart Battery. Watch the Weight in Your Golf Cart.
Does a Club Car golf cart have a governor?
Locate the golf cart’s governor; you can find the governor by tracing the thickest cable running from the gas pedal. This cable runs through the governor on its way to the carburetor. You have now adjusted the governor for faster speed.
How do you adjust the governor on a EZ Go golf cart?
How to Adjust the Governor on a Gas E-Z-Go Golf Cart Locate the governor arm mounted on top of the rear axle case underneath the cart. Loosen the adjusting locknut on the end of the governor spring. Retighten the adjusting locknut.
Does electric golf cart have governor?
Considering electric golf carts don’t have governors like gas powered carts, the old-school method of simply removing the governor is not an option.
Is there a speed limiter on an electric golf cart?
For the most part, golf carts are designed to top out at 15 miles per hour on the course. Basically, an electric speed governor can be controlled by a tiny metal rod that’s located by the clutch of your golf cart.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
Is 30 mph fast for a golf cart?
Generally speaking, golf carts are low-speed vehicles. Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
Why is my gas golf cart slow?
Low Battery Usually, the most common reason golf carts slow down is when they don’t get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do I speed up my electric EZ Go golf cart?
Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.
How do I turn off the governor on my club car?
Look behind the governor to find a small metal rod that’s permanently attached to the club car and stretch your rubber band enough to connect it to that metal rod. Screw the plastic plate back in place. Once the plate is back in place, the governor is disabled.
What does a governor do on a golf cart?
The ground speed governor, as it’s called among the golf cart manufacturers, is a mechanical device usually either inside or in someway related to the differential, which controls your top end flat ground speed to prevent the rpms of the engine from exceeding recommended specifications.
How can I speed up my 36 volt golf cart?
How to Make a 36 Volt Golf Cart Faster Remove any unnecessary additions, racks or parts on your golf cart. Power-wash your cart. Check the shaft under the ignition pedal. Put larger tires on the cart. Replace any old or worn-out parts that are causing the cart to move slower than it should.
How fast is 48V golf cart?
Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires – You can purchase larger tires.
Can I put bigger tires on my golf cart?
All non-lifted golf carts can take 18.5″ tall tires, but some can take a little bigger, i.e., EZGO & Yamaha Drive can take 20″ without a lift. What High Profile / All-Terrain style tires/wheels can I put on Lifted Golf Carts? Lifted golf carts can fit ANY 8” tire, low profile OR high profile.
How do I increase the torque on my electric golf cart?
Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.
How long do golf cart batteries last?
When you drive a battery-powered golf cart model, it’s important to charge it correctly and maintain your cart so that your battery will last as long as possible. When you take care of your golf cart’s battery, you can expect it to last anywhere between five and ten years.
