Table of Contents
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
How do you remove the speed limiter on a EZ Go golf cart?
General Instructions Detach the cable from the carburetor. The cable is about the width of a straw. Follow the disconnected cable up to the governor. Disconnect the gas pedal cable from the governor and reroute it to the carburetor. Using your wrench, remove the bolt on the gas pedal shaft.
How can I make my EZ Go TXT 36 volt faster?
6 Ways You Can Make a Golf Cart Faster Add More Torque to Your Golf Cart. Upgrade Your Golf Cart’s Motor. Improve the High-Speed Controller of the Cart. Add Better Golf Cart Tires. Use a Higher Powered Golf Cart Battery. Watch the Weight in Your Golf Cart.
How do you adjust the governor on a EZ Go golf cart?
How to Adjust the Governor on a Gas E-Z-Go Golf Cart Locate the governor arm mounted on top of the rear axle case underneath the cart. Loosen the adjusting locknut on the end of the governor spring. Retighten the adjusting locknut.
How do I make my EZ Go golf cart go faster?
Tighten the governor spring located in the engine of most golf carts to adjust your cart’s top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
How do I make my EZ Go TXT golf cart go faster?
Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.
Why is my ezgo golf cart so slow?
Low Battery Usually, the most common reason golf carts slow down is when they don’t get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
Is 30 mph fast for a golf cart?
Generally speaking, golf carts are low-speed vehicles. Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
How can I make my 36 volt golf cart faster?
How to Make a 36 Volt Golf Cart Faster Remove any unnecessary additions, racks or parts on your golf cart. Power-wash your cart. Check the shaft under the ignition pedal. Put larger tires on the cart. Replace any old or worn-out parts that are causing the cart to move slower than it should.
How fast does an ezgo golf cart go?
Electric Motors Looking at the specifications for EZ Go electric golf carts, you notice a cart with a 36-volt motor is capable of 12 to 14 mph top speed. In addition, you notice a cart that’s powered by a 48-volt motor can reach speeds just below 20 mph.
What does a speed controller do on a golf cart?
The controller meters out current and voltage on your battery based on user input, whether that be a gas pedal, a throttle, or even pedals on a bicycle. With the controller you are able to control your acceleration and deceleration, as well as the speed at which your vehicle moves.
How fast does a 36v golf cart go?
How fast is a 36 volt golf cart? Without any upgrades, you can plan on max speeds between 12-14 mph.
How can I make my golf cart gas faster?
Increase the RPM An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.
Where is the speed sensor on a ezgo golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without Upgrades Wash Your Cart Properly. Inspect the Batteries. Refill the Battery Water. Check the Gas Pedal and Linkage. Measure the Tire Pressure. Charge Up Your Battery Unit. Lighten Up Your Cart’s Weight.
Can you adjust the speed on an electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that’s located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
Are gas or electric golf carts faster?
Surprisingly, electric carts actually have a higher top speed than gas carts. A gas cart can run up to 18 – 20 mph and there are not many speed upgrades you can do to one. In addition, electric carts will get up to top speed faster as well.
