Table of Contents
The average cost of a condenser fan motor is between $300 and $500 (not including installation). If the compressor breaks, you are looking at a much costlier problem which could cost up to $2000. In some cases, your fan motor may be under warranty.
How much does it cost to replace fan motor on AC unit?
When your air conditioner’s fan motor breaks, it will typically cost about $300 to $600 to replace. It’s imperative to get this fixed quickly, since without a working fan motor your air conditioner’s compressor can be the next domino to tumble. Its repair is even more significant — usually running closer to $2,000.
How do I know if my AC fan motor is bad?
Be aware of the following signs and symptoms of a bad AC fan motor. AC Fan Doesn’t Start. Even though you have the AC turned on, the fan does not start. AC Fan Doesn’t Stop. Slow Rotating Blades. Outside Fan Blades Are Still. Rattling, Humming, and Buzzing Noises. AC Runs Intermittently. No Cold Airflow.
Can I replace an AC fan motor myself?
Every time you replace a condenser fan motor, you should also replace the A.C.’s run capacitor, which is a cylinder-shaped device that helps to start or run motors. To replace it, again take down all technical data on the unit, and note wiring colors and positions before removing it with a screw driver.
How much does an AC fan cost?
Cost to Replace Condenser Fan Motor Average Cost $400 High Cost $600 Low Cost $300.
Why would my AC fan stop working?
One of the most common reasons fans stop spinning is because of a dead capacitor. Each air conditioning system has several capacitors, including the start capacitor, which sends signals to the motor, and the run capacitor, which keeps the motor running. Capacitors can go bad over time and need to be replaced.
What causes fan motor to overheat?
Lack of maintenance: This is probably the most common reason that causes condenser fan motors to overheat and shut off. Proper and regular lubrication of the fan motor is necessary for the motor to run smoothly. If the motor is too small, it will run too hard and then overheat.
What does a bad AC fan motor sound like?
Screeching Sounds If your air conditioner is making a shrieking noise, this is an indicator of an issue with the fan motor. This sound may also be caused by a broken motor in the compressor of the condenser system. A screeching or squealing noise may also be caused by a damaged blower fan motor inside your house.
What happens when AC motor goes out?
The fan won’t start even though the AC is on. The fan won’t stop, even when you shut the AC off. The fan turns on, yet the blades are rotating very slowly. There’s a rattling noise coming from the condenser unit when the fan is turned on.
When should I replace my AC fan motor?
If the run capacitor was bad, you should allow the fan motor to cool. Then you can turn the unit back on and see if the motor starts and comes up to speed. If the fan fails to start or does not run at full speed, it should be replaced.
How long should an AC blower motor last?
The blower motor in your home or office should last anywhere from 10 to 20 years. Modern sealed bearings and sealed bushings can push the lifespan to its maximum of 20 years. Proper cleaning and maintenance can also extend your unit’s lifespan.
How much does it cost to replace a fan motor in a car?
“A new car blower motor costs about $50 to $100 for the part and $80 to $100 in labor. Add it up and you’re looking at a total charge of $130 to $200 for a new car blower motor.
Can AC work without fan?
If the fan is not running it will not be able to remove the heat. This is a big no no, and you could fail the compressor and other components. If you are in a huge pinch, you can use a large box fan blowing on top of the unit and down into it, or pulling the hot air out, this will buy you very little time.
Why is my outside AC fan not spinning?
If the fan takes off and then keeps going on its own, you more than likely have a bad start capacitor. If the fan doesn’t start running, you may have a bad fan motor. If you have difficulty getting the blades to turn, there may be debris wrapped around the fan axle, or the motor bearings may be dirty or jammed.
Can you run a fan without AC?
Why You Should Run the Blower Fan Without the AC Constantly turning the fan on and off can cause wear and tear to your system, which can reduce its lifespan. Over time, this may cause more frequent breakdowns. To avoid this, it may be best to leave the fan on.
Can an AC fan motor overheat?
Most condenser fan motors have been designed to operate at temperatures up to around 150F. When there is something wrong with the fan motor, it can overheat and cause problems with the HVAC system.
What happens if a fan motor overheats?
Telltale Signs Of Overheating Condenser fan motors overheat when they reach a temperature of roughly 150 degrees Fahrenheit. Upon overheating, the motor will stop running, halting the HVAC system and potentially damaging other vital components.
What happens if a electric motor overheats?
Experts suggest that an 18°F (10°C) degree increase in motor winding temperature can directly affect the insulation of the component and reduce its lifespan by 50%. This has an irreversible impact on the lifespan of your machinery, regardless of whether the overheating was temporary or long-lasting.
