Table of Contents
You can put new concrete over old concrete. However, unresolved issues with your old concrete, such as cracks or frost heaves, will carry over to your new concrete if not taken care of. In addition, you must pour it at least 2 inches thick.
Can new concrete match old concrete?
We decided to expand them and discovered a way to make the old concrete match the new concrete. It’s called Concrete Resurfacer. You can buy it at Home Depot, Lowes, and even Amazon. Now you can do any concrete project and make it match your existing concrete!.
How do you attach concrete to old concrete?
Drill 5/8-inch diameter holes six inches deep into the old concrete. Flush the holes with water. Inject epoxy into the backs of the holes. Insert 12-inch lengths of rebar into the holes, twisting them to ensure an even coating of epoxy around their circumferences and along their lengths within the holes.
What can I put over cracked concrete?
Lastly, the most popular way to patch up cracks formed in concrete is with polymer resin. This option is the most expensive DIY option as it not only fills the entire depth of the break but also forms a permanent chemical bond with the concrete slab, gluing the slabs together to seal it from any structural moisture.
What is concrete overlay?
Answer: A concrete overlay is a thin color concrete cement based products that go over existing concrete for repair or decorative reasons. Overlays can be applied as thin as a feather finish up to in most cases 3/4″ depending on the desired finish.
Can I pour concrete over dirt?
Long story short, yes you can pour concrete over dirt.
How thick should concrete overlay be?
The minimum recommended thickness is 1 to 2 in. (25 to 50 mm) for a fully bonded concrete overlay placed on a base slab that is practically free of cracks and in which the concrete is sound, clean, and of good quality.
What is the best adhesive for concrete to concrete?
When it comes to reliability, we consider Loctite as the best adhesive for concrete blocks. Loctite adhesive offers enhanced adhesion to nearly all construction materials. It’s suitable for both indoor and outdoor projects plus is nearly three times stronger than ordinary construction adhesives.
How do I keep my concrete patio from cracking?
If you’re having new concrete poured consider the following ways to prevent cracking: Start with a sound subgrade. Make sure the subgrade is compacted. Modify the concrete mix. Use a low water-to-cement ratio. Install joints. Be active in deciding where control joints will be placed. Properly cure the concrete.
Can cracked concrete be resurfaced?
Concrete resurfacing to cover larger cracks or surface problems. Large cracks or holes greater than ¼”, spalling (horizontal peeling or chipping of the surface), and discoloration can be covered with resurfacing or a concrete overlay (a thin layer of cement-based material applied directly over the existing concrete).
Should you fix hairline cracks in concrete?
That said, hairline cracks in concrete can worsen over time if not dealt with. During colder seasons, water can get inside the crack and freeze, causing it to expand. If deep cracks cover the surface of the concrete, then it might be best to replace the concrete entirely.
Do concrete overlays last?
How long is the life span of a decorative concrete Overlay? If maintained and sealed properly, the DCO can last 20 years and be a permanent topping to the concrete slab. Every 5 to 7 years it should be resealed.
Is concrete overlay expensive?
Concrete Overlay Cost for Floors, Patios & More. A basic floor overlay runs from $3 to $7 per square foot, which is comparable to high-end carpet or tile. The price can increase to $20 or more per square foot depending on textures, embeds, saw cuts, or other design elements that are added to the design.
Does concrete overlay hold up?
These typically need 1/4 inch of thickness to hold up long-term. They gain strength from thickness, and if underapplied, they will not hold up very long. A lesser-known problem with thicker overlays, especially stampable systems, occurs when the surface is finished too early or too aggressively.
How can I make my concrete driveway look good?
6 Ways to Give Your Driveway That Unique Look #1: Etching. Nothing sets your driveway apart from the rest like etching. #2: Staining. Tired of plain old gray? #3: Stamping. Similar to staining or etching, concrete stamping can also spruce up your driveway with color and a pattern. #4: Weeding. #5: Pavers. #6: Resin Bound.
Does concrete stick to concrete?
QUIKRETE® Concrete Bonding Adhesive (No. 9902) permanently bonds new concrete, plaster, and stucco to existing concrete, plaster, and stucco. Eliminates the need for roughing the surface before the application.
How do you fix a crumbling concrete driveway?
Mix one part Type 1 Portland cement and one part fine sand by volume. Add water until the mixture is the consistency of thick paint, then brush it on the damp concrete.
Do I need gravel under concrete?
Whether you pour concrete for a walkway or patio, a strong gravel base is required to prevent the concrete from cracking and shifting. Gravel is especially important in clay soil because it doesn’t drain well, which results in water pooling under the concrete slab and slowly eroding the soil as it finally drains.
Do you need to put plastic under concrete?
Water vapor will always move from a high relative humidity environment below the building into an area of low relative humidity – even through concrete. That’s why nearly every expert in the concrete industry recommends a below-slab vapor barrier to stop the vapor drive of water upward and into your building envelope.
What kind of gravel goes under concrete?
Most concrete contractors want a mix of coarse and fine aggregate to create a compactable base that is going to be safe for settlement and drainage. Crusher run (a mix of crushed stone and stone dust) is one of the best base materials for concrete flatwork.
