Table of Contents
You can put new concrete over old concrete. However, unresolved issues with your old concrete, such as cracks or frost heaves, will carry over to your new concrete if not taken care of. In addition, you must pour it at least 2 inches thick.
Does concrete stick to concrete?
QUIKRETE® Concrete Bonding Adhesive (No. 9902) permanently bonds new concrete, plaster, and stucco to existing concrete, plaster, and stucco. Eliminates the need for roughing the surface before the application.
How do you attach concrete to old concrete?
Drill 5/8-inch diameter holes six inches deep into the old concrete. Flush the holes with water. Inject epoxy into the backs of the holes. Insert 12-inch lengths of rebar into the holes, twisting them to ensure an even coating of epoxy around their circumferences and along their lengths within the holes.
How do you pour new concrete on top of old?
If done properly, new concrete can often be poured right over an existing slab. For this to be feasible, the contractor needs to pour at least 2 inches thick, use smaller aggregate, and incorporate reinforcement such as welded wire mesh or fiber mixed into the concrete.
What is poor man’s concrete?
We have a few companies locally that offer “poor man’s concrete”. I’m not sure exactly what it is, but I’ve seen it in driveways and such. It’s a white powdery material they dump and flatten out and when it gets wet, it’s supposed to harden like cement.
Can you put a thin layer of concrete over concrete?
How Thin Can You Pour Concrete Over Existing Concrete? The thinnest that is usually used when pouring concrete, in general, is about 2 to 2 ½ inches. That also applies to this pouring new concrete over old concrete. Any thinner than 2 inches would be too thin.
Can I pour concrete over dirt?
Long story short, yes you can pour concrete over dirt.
What is the best adhesive for concrete to concrete?
When it comes to reliability, we consider Loctite as the best adhesive for concrete blocks. Loctite adhesive offers enhanced adhesion to nearly all construction materials. It’s suitable for both indoor and outdoor projects plus is nearly three times stronger than ordinary construction adhesives.
How thick should concrete overlay be?
The minimum recommended thickness is 1 to 2 in. (25 to 50 mm) for a fully bonded concrete overlay placed on a base slab that is practically free of cracks and in which the concrete is sound, clean, and of good quality.
What can I do with my concrete slab in my backyard?
Take a look at all of these fabulous concrete patio ideas. Paint a Pattern. Yes, you can paint your concrete slab. Lay Decking Flooring. Did you know you can lay decking over a concrete slab? Add Curves With Pavers. Lay Slate Tiles. Stain the Concrete to Look Like Tile. Add a Beautiful Outdoor Rug. Paint Concrete. Dress it Up.
Can you put exposed aggregate over existing concrete?
It can be applied to any concrete that has been cured for a minimum of 28-days. It is a spray-on application that is 2-3mm thick on top of the existing concrete. We can then work with this to create a plain, speckled or flecked finish that looks like exposed aggregate.
What are the alternatives to concrete?
19 Concrete Alternatives Bamboo. Maybe you didn’t see this coming or maybe you did, depending on which part of the world you live in. Steel. For starters, steel can be separated and has raw materials that are great for recycling. Wood. We all know this one. Straw Bale. Hempcrete. Timbercrete. Papercrete. Mycelium.
What is a good substitute for concrete?
Concrete: Cement Substitutes Pulverised Fuel Ash (PFA), aka ‘Fly ash’ as a cement substitute. PFA is a by-product of coal-burning power stations. Ground Granulated Blast-furnace Slag (GGBS) as a cement substitute. GGBS is a by-product of the iron and steel industry. Silica fume. Limestone fines. Alternative fuels.
What is the cheapest way to make concrete?
One of the least expensive ways to get concrete is to mix your own. You can buy bags of the mix from a home improvement store. Typically, you only have to add water for it to be ready to pour. However, it is important to get the ratio right and to mix the concrete thoroughly.
Does Gorilla Glue work on concrete?
Gorilla 2 Part Epoxy is useful for gap-filling, repairing exterior siding, or gluing plastic, wood, metal, ceramics, brick, stone, concrete, glass, and foam. The epoxy is water-resistant (though not waterproof) so it can hold up fairly well when used on outdoor items.
Will concrete overlay last?
How long is the life span of a decorative concrete Overlay? If maintained and sealed properly, the DCO can last 20 years and be a permanent topping to the concrete slab. Every 5 to 7 years it should be resealed.
Do I need gravel under concrete?
Whether you pour concrete for a walkway or patio, a strong gravel base is required to prevent the concrete from cracking and shifting. Gravel is especially important in clay soil because it doesn’t drain well, which results in water pooling under the concrete slab and slowly eroding the soil as it finally drains.
Can I use pea gravel under concrete?
If the soil is disturbed and packed or unstable such as some clays, a base will provide a solid underpinning for the slab. If you use crushed rock and dust, it will need to be packed. It will pack substantially. Pea gravel, on the other hand won’t pack.
Do you need to put plastic under concrete?
Water vapor will always move from a high relative humidity environment below the building into an area of low relative humidity – even through concrete. That’s why nearly every expert in the concrete industry recommends a below-slab vapor barrier to stop the vapor drive of water upward and into your building envelope.
How do you attach something to concrete without drilling?
If you are willing to make holes in the concrete but do not want to buy the particular drill bit needed, then the simplest solution is to get nails for your project. Standard nails will not work on concrete, but some nails are made specifically for nailing wood to concrete. Cut nails will also work for this as well.
Can I use liquid nails on concrete?
LIQUID NAILS® Concrete & Mortar Repair, (CR-805), is a weather-resistant indoor/outdoor acrylic compound with silicone, ideal for repairing and sealing cracks and joints in concrete and masonry surfaces. This easy-gunning sealant dries gray similar to concrete or can be painted.
How do you attach metal to concrete without drilling?
Concrete anchor bolts work best to attach metal to concrete. Steel can be attached to concrete without screws or glue by using concrete anchors and bolts. Alternatively, you could cast the concrete with the metal embedded in the concrete.
