Table of Contents
The most common reasons a radiator fan is not working are luckily due to a blown fuse, bad relay, or a broken wire. It can also be caused by a faulty coolant temp sensor, low coolant level or the fan itself can be damaged.
Can I drive car if radiator fan is not working?
As such, you should never drive your vehicle if the cooling fan isn’t working even though you can. If the radiator does not have cool air blowing on it constantly, it will overheat eventually, so you’d need the perfect combination of weather and traffic to drive effectively without a radiator fan.
What happens if radiator fan not working?
What happens when a radiator fan stops working? It will cause a loud whirring noise and a stuck open thermostat (which will not allow the engine to reach the average operating temperature). A lousy radiator cooling fan could cause a blown circuit fuse, a malfunctioning relay, and engine overheating.
How can I tell if my radiator fan is working?
A simple way to check if the radiator fan is working is to start your engine and turn the air-conditioning system (A/C) to the maximum speed. If the fan is spinning, then it means that the fan motor, fuse, wiring, and relay are all working properly.
How do you know if your radiator fan is broken?
These are the most common signs of a faulty radiator fan assembly in need of replacement: Engine Overheating. When the radiator fan isn’t functioning properly, it is not able to adequately cool down the car’s engine. Air Conditioner Function Diminished. Loud Noise Coming From Radiator Fan.
Why does my radiator fan not turn off?
Pull the cooling fan relay out of the box. Replace the cooling fan relay with a new one. A stuck closed relay is the only thing that can operate the cooling fan continuously with the key off. The computer looses power with the key off and the same applies to the coolant temperature sensor.
Should radiator fan come on when car starts?
The engine temperature should trigger the fan to turn on. It will also turn the fan off once the engine has cooled to under 200 degrees. You may have heard of a part called the radiator fan switch or temperature fan switch.
How much does it cost to replace a radiator fan?
The average radiator fan replacement cost is typically between $550 and $650. In many cases, the radiator fan will cost around $400 to $450, while the labor adds $150 to $200. However, some vehicles can be more expensive, depending on the design.
How can you tell if a fan fuse is blown?
Look at the fuse wire. If there is a visible gap in the wire or a dark or metallic smear inside the glass then the fuse is blown and needs to be replaced.
How long do radiator fans last?
Your car fan will run for a few minutes after you turn off the car then turn it off. This is normal in many vehicles, such as BMW or Mercedes-Benz. The radiator fan may run up to five minutes and sometimes longer. Unless there is an electrical issue, it may stay on all the time until it drains the battery.
What causes engine fan failure?
ELECTRIC COOLING FAN PROBLEMS Defective temperature switch, coolant sensor or other sensor. Engine thermostat is stuck OPEN (engine never gets hot enough to turn on the fan) Faulty fan relay. A wiring problem (blown fuse, loose or corroded connector, shorts, opens, etc.).
Why is my radiator fan still running?
It’s normal for some vehicles to have a fan run for a few minutes after the car is shut off, generally to keep the engine cool. However, if the fan is running for an extended period, the fan itself can become damaged due to overuse. It’s possible you may have a module or relay failing in your car.
How often do radiator fans need to be replaced?
In most cases, a properly maintained radiator fan will last between eight and ten years. When the radiator fan fails, it should be replaced as soon as possible. This is because without a cooling fan to help remove heat from the engine, your car is more likely to overheat and cause damage to important engine components.
Is there a fuse for the radiator fan?
If your car’s radiator fan is non-functional, check your car’s user manual and locate the fuse for the radiator fan controller or the fan. The fan itself often uses a big fuse of around 50A, while there might also be a separate small fuse to the fan control module.
Why does my fan stop spinning?
One of the most common reasons fans stop spinning is because of a dead capacitor. Each air conditioning system has several capacitors, including the start capacitor, which sends signals to the motor, and the run capacitor, which keeps the motor running. Capacitors can go bad over time and need to be replaced.
Where is the relay for cooling fan?
The fan relay is usually located near the bottom of the engine compartment on a metal frame member. The metal acts as a heat sink to keep the fan relay cool. So, unplug the connector at the relay and repeat the check for power. If you get power, you’ve got a bum relay.
Where is the fuse for the fan motor?
Under the instrument panel, look under the glove box. On the right side of the fender wall you will find another fuse box. The blower motor fuse is easy to replace.
