Table of Contents
The dryer belt goes around the outside of the drum and is looped onto a drive pulley attached to the dryer motor shaft which drives the belt, and around an idler pulley which applies tension to the belt. This tension is what causes the belt to grip the outside of the drum in order to rotate it.
Is it hard to replace dryer belt?
One of the most common causes for a clothes dryer to fail is a broken drive belt on the dryer drum. This is an easy do it yourself repair, which uses very few tools, and can save a lot of money.
How do I know if my dryer belt is broken?
Inspect your dryer’s belt. If it is excessively worn, has little cracks, or is broken altogether, you will have to replace it. With your dryer opened up, you’ll notice that the belt loops over the drum, under the idler pulley wheel, and around the motor’s drive pulley.
How much does it cost to replace a dryer belt?
Dryer Belt Replacement Replacing a dryer belt costs about $200 if you hire a pro, or $10 to $20 for DIY.
What causes a dryer belt to break?
A dryer belt wrapped around the drum’s exterior causes it to turn. Over time, the belt will wear out and eventually break, which will prevent the drum from rotating, and the dryer from functioning properly.
How do you fix a broken belt on a dryer?
Instructions Shut off the power. Unplug the dryer. Raise the top panel. Pull the lint screen out of the housing in the top panel of the dryer. Remove the front panel. Remove the drive belt. Install the new drive belt. Reinstall the front panel. Reassemble the top panel. Restore power to the dryer.
Why is my dryer drum not spinning?
If the dryer doesn’t spin, it could be that the rubber drive belt looped around the dryer drum is either stretched out too much and not causing enough friction to turn. The dryer not spinning could mean that you have a broken drive belt.
Are all dryer belts the same?
Typically, a standard size belt will be a few inches longer than double the conveyor dryers length. For example, an 8 foot dryer might have a belt that is 16 feet, 3 inches (195” overall).
Can I use a dryer with a broken belt?
When Belt Breaks Over time, wear can weaken the belt until it reaches its breaking point. When a dryer belt breaks, the drum no longer turns to tumble the clothes in the dryer’s hot air. This means clothes won’t dry even if the dryer’s heater and electric motor continue to function.
Do dryer belts go bad?
A Bad Belt Has To Be Replaced When the belt can’t turn the drum, sometimes the motor is to blame. If the motor is fine and the belt is loose or broken, the repair person will open the dryer top and front to reach the belt and drum.
Can a dryer belt cause a fire?
The burning smell from your dryer may be lint buildup or another common problem—such as a failing thermostat, motor, or belt. About a third of those fires are caused by excess lint buildup inside the dryer, so it’s time to investigate.
Why does my dryer sound like it has rocks in it?
The rumbling or thumping sound could be caused by worn drum support rollers. The drum rollers support the dryer drum on some models and makes of dryers (like those made by Kenmore or Whirlpool.) To access the two back dryer drum support rollers, you will need to remove the dryer drum from the cabinet.
Is it worth fixing a dryer?
Is it worth repairing a dryer? Dryer repairs are worth it if the appliance is less than 4 years old and the cost is less than $400. For older dryers and/or costly repairs, replacing your appliance is more cost effective.
Why does my dryer get hot but not dry clothes?
There are several reasons why the dryer is heating up, but still not drying clothes and it might take several hours to finally get them dry. The reasons are: clogged exhaust vent, faulty heating element, malfunctioned cycling thermostat or clogged lint trap.
How do I know if my dryer drum is bad?
You can check the drum rollers by opening the dryer door and looking at the back of the wall. The drum support rollers should be checked if there is a gap between the rear of the tumbler and the back wall.
Do tumble dryers have belts?
The belt in your tumble dryer goes all around your drum, and then over the motor on one side, allowing the motor to then turn the drum. If the drum is failing to turn, then there could be an issue with the drive belt.
What sizes do dryer belts come in?
if you search dryer drive belts you will find out that they sell three different size belts. A 92 1/4″ belt, an 87 3/4″ belt and a 93″ belt.
How do you replace a belt on a Kenmore front load dryer?
Pull the idler pulley toward you to loosen the strain on the dryer belt. Use your fingers to remove the dryer belt from the idler pulley. Remove the dryer belt from around the dryer drum. Wrap the new dryer belt around the dryer drum and then pull the idler pulley toward you.
Why do my clothes smell like gas after drying?
In most cases, a gas smell on the interior of your gas dryer or on your freshly laundered clothing is a sort of ventilation problem. When there is an exhaust system breach, essentially the dryer intake may be pulling in some of the dryer’s own exhaust which commingles with your clothing and makes them a bit smelly.
Why does my electric dryer smell like rotten eggs?
Providers of natural gas add the scent of mercaptan to the fuel for safety. Mercaptan is an acrid chemical that has a smell similar to sulfur or rotten eggs. Mercaptan is found naturally when you cut into an onion, or during the decay of plant or animal matter.
How do I get the poop smell out of my dryer?
Wipe out all the poop smears with a rag soaked in vinegar. Wipe the front door and other areas. Wet a large towel and put it through the dryer on steam cycle. Wipe the entire interior of the dryer with bleach on a rag.
Why is my dryer so loud all of a sudden?
When the drum rollers are worn out, they can cause the dryer to make a loud rumbling noise. Over time, the drum rollers and axles wear out, causing the dryer to make a loud rumbling noise. To determine if the drum roller axles are worn out, remove the belt from the dryer and try turning the drum by hand.
How many years does a dryer last?
The average clothes dryer lasts between eight and 12 years, according to Angie’s List. But the more you use that dryer, the shorter its lifespan is likely to be. Also, a higher-quality dryer is likely to outlast a cheaper model with inferior components.
Can I fix my dryer myself?
If your dryer breaks down Here’s the first thing to know about dryer repair: You can solve most dryer troubles yourself. There’s no need to find a technician, schedule a service call or pay hundreds dollars for dryer repair. Tip: The first step in any appliance repair is to make sure it’s getting electricity.
How much should a dryer repair cost?
The average cost of repairing a dryer is around $100 to $400, which will generally cover most drum issues (such as a broken belt), a faulty thermostat, or clogged vents. If you’re unsure whether or not a repair is worth it, refer to the 50% rule.
